考虑搅拌时间的洞庭湖区 水泥土无侧限抗压强度试验及模型探讨

殷晓慧 费大伟 黄耀英 方国宝 蔡忍 周勇

PDF(2025 KB)
中国农村水利水电 ›› 2019 ›› (11) : 188-193.
水工建筑

考虑搅拌时间的洞庭湖区 水泥土无侧限抗压强度试验及模型探讨

  • 殷晓慧1,费大伟1,黄耀英2,方国宝1,蔡忍1,周勇1
作者信息 +

Unconfined Compressive Strength Test and Model Discussion of Cement Soil in Dongting Lake Area Considering Mixing Time

  • YIN Xiao-hui 1 ,FEI Da-wei 1 ,HUANG Yao-ying1 ,FANG Guo-bao2 ,CAI Ren1 ,ZHOU Yong1
Author information +
稿件信息 +

摘要

针对搅拌时间影响因素对水泥土强度性能影响的研究不足,本文结合洞庭湖区某分洪闸工程的淤泥质土地基,探讨搅拌时间以及其它不同影响因素对水泥土无侧限抗压强度的影响。采用正交试验法开展3种不同水灰比、水泥掺入比、搅拌时间和养护龄期的室内水泥土无侧限抗压强度试验,进而假设4个影响因素之间无相互影响用乘积模型建立了多因素影响的水泥土无侧限抗压强度模型,并采用优化算法识别了新模型的参数。研究表明,不同养护龄期下影响水泥土无侧限抗压强度的因素重要性次序分别为水灰比、水泥掺入比、搅拌时间。水灰比和水泥掺入比与水泥土无侧限抗压强度基本呈抛物线关系,而搅拌时间和养护龄期与水泥土无侧限抗压强度基本呈对数关系。综合考虑搅拌时间等多因素影响的水泥土无侧限抗压强度模型计算值与试验数据拟合良好,对实际水泥土工程具有一定指导。

Abstract

In view of the insufficiency of the influencing factors of mixing time on the strength properties of cemented soil,this paper combines the muddy soil foundation of a flood gate project in Dongting Lake area to discuss the influence of mixing time and other different influencing factors on the unconfined compressive strength of cement soil. The unconfined compressive strength test of indoor cement soil with different water-cement ratios,cement mixing ratios and mixing time under different curing ages is carried out by orthogonal test method, assuming four influencing factors ( water-cement ratio,cement) . There is no mutual influence between the mixing ratio,mixing time and curing age. Then the multi-factor-affected cement soil unconfined compressive strength model is established by the product model,and the parameters of the model are identified by the optimization algorithm. The research shows that the order of importance of factors affecting the unconfined compressive strength of cement soil under different curing ages is water-cement ratio,cement mixing ratio and mixing time. The water-cement ratio and cement mixing ratio are basically parabolic with the unconfined compressive strength of cemented soil,while the mixing time and curing age are basically logarithmic with the unconfined compressive strength of cemented soil. Considering the multi-factor effect of mixing time,the calculated values of the unconfined compressive strength model of cemented soil are well fitted with the experimental data,and can be applied to the prediction of unconfined compressive strength of cement soil,which has certain effect on actual cement soil engineering.

关键词

水泥土 / 正交试验法 / 无侧限抗压强度 / 搅拌时间 / 强度模型

Key words

cement soil / orthogonal test method / unconfined compressive strength / mixing time / strength model

基金

国家自然科学基金资助项目( 51779130) 。

引用本文

导出引用
殷晓慧 费大伟 黄耀英 方国宝 蔡忍 周勇. 考虑搅拌时间的洞庭湖区 水泥土无侧限抗压强度试验及模型探讨[J].中国农村水利水电, 2019(11): 188-193
YIN Xiao-hui, FEI Da-wei, HUANG Yao-ying, FANG Guo-bao, CAI Ren, ZHOU Yong. Unconfined Compressive Strength Test and Model Discussion of Cement Soil in Dongting Lake Area Considering Mixing Time[J].China Rural Water and Hydropower, 2019(11): 188-193

参考文献

[1]王立华, 罗素芬, 陈理达.水泥土搅拌桩室内配合比试验研究[J].广东水利水电, 2008, (11):115-115 [2]曹智国.水泥土强度特征与搅拌桩复合地基可靠度分析[D].东南大学, 2015. [3]席培胜, 刘松玉, 张八芳.水泥土搅拌桩搅拌均匀性的电阻率评价方法[J].东南大学学报(自然科学版), 2007, (02):355-358 [4]陈瑞生, 蔡荣坤.水泥土无侧限抗压强度的影响因素分析[J].中外公路, 2005, (02):140-142 [5]汤怡新, 刘汉龙, 朱伟.水泥固化土工程特性试验研究[J].岩土工程学报, 2000, 22(5):549-554 [6]阮波, 阮庆, 田晓涛, 等.淤泥质粉质黏土水泥土无侧限抗压强度影响因素的正交试验研究[J].铁道科学与工程学报, 2013, 10(06):45-48 [7]HORPIBULSUK S, MIURA N, NAGARAJ T S.Clay-water cement ratio identity of cement admixed soft clays[J].Journal of Geotechnical and Geoenvironmental Engineering, 2005, 131(2):187-192 [8]HORPIBULSUK S, MIURA N, NAGARAJ T S.Assessment of strength development in cement-admixed high water content clays with Abram’s law as a basis[J].Geotechnique, 2003, 53(4):439-444 [9]MIURA N, HORPIBULSUK S, NAGARAJ T S.Engineering behavior of cement stabilized clay at high water content[J].Soils and Foundations, 2001, 41(5):33-45 [10]郭涛.水泥土搅拌桩施工工艺优化现场试验研究[J].湖南工程学院学报自然科学版, 2012, 22(01):84-87 [11]孙快忠.基于龄期的水泥土强度预测分析[J].西部探矿工程, 2014, 26(03):181-183 [12]张石友, 陈艳国, 赵自文.不同水泥掺量的水泥土无侧限抗压强度预测[J].人民长江, 2015, 46(11):68-70 [13]储诚富, 洪振舜, 刘松玉, 等.用似水灰比对水泥土无侧限抗压强度的预测[J].岩土力学, 2005, (04):645-649 [14]赵春彦, 黄启友, 郎锋, 等.单因素和多因素作用下的水泥土强度评估模型试验研究[J].铁道科学与工程学报, 2018, 15(11):2788-2795 [15]李云雁, 胡传荣.试验设计与数据处理[M].北京:化学工业出版社, 2005. [16]师义民, 徐伟, 秦超英, 等.数理统计[M].北京:科学出版社, 2009. [17]梁仁旺, 张明, 白晓红.水泥土的力学性能试验研究[J].岩土力学, 2001, (02):211-213 [18]王贤昆, 庞建勇, 王强.复合水泥土无侧限抗压强度正交试验研究[J].长江科学院院报, 2015, 32(12):72-75 [19]姚贤华, 管俊峰, 谢超鹏, 等.砂质粉土水泥土无侧限抗压强度试验[J].南水北调与水利科技, 2016, 14(2):125-130 [20]阮庆, 阮波, 曾元, 等.洞庭湖区淤泥质黏土水泥土力学性能试验研究[J].铁道科学与工程学报, 2014, 11(05):106-111 [21]陈达, 庄宁, 廖迎娣, 等.水泥土力学特性随龄期发展规律试验研究[J].水利水运工程学报, 2012, (01):26-29 [22]胡运权, 等.运筹学基础及应用[M].北京:高等教育出版社, 2010.
PDF(2025 KB)

访问

引用

详细情况

段落导航
相关文章

/